Effects of the feed rate, the amount of catalyst and the reaction temperature on the multiphase dehydrogenation reaction of isopropanol in a liquid film reactor with the amorphous alloy Raney nickel as catalyst were studied. The reaction kinetics was researched. The results showed that the effect of temperature was the most significant factor. Compared with the liquid phase dehydrogenation of the stirred tank, this reaction mode effectively improved the hydrogen production rate. The kinetic of Langmuir?Hinshelwood was obtained which agreed well with the experimental results.
Shikun LI Min XU Jun CAI Xianfang YUE Xiulan HUAI
. Dehydrogenation Performance and Reaction Kinetics of Isopropanol in Liquid Film Reactor[J]. The Chinese Journal of Process Engineering, 2018
, 18(3)
: 652
-656
.
DOI: 10.12034/j.issn.1009-606X.217333
[1] Ajah A N, Mesbah A, Grievink J, et al. On the robustness, effectiveness and reliability of chemical and mechanical heat pumps for low-temperature heat source district heating: a comparative simulation-based analysis and evaluation[J]. Energy, 2008, 33(6): 908-929.
[2] Kitikiatsophon W, Piumsomboon P. Dynamic simulation and control of an isopropanol–acetone–hydrogen chemical heat pump[J]. Science Asia, 2004, 30(1): 135-147.
[3] Ajah A N, Mesbah A, Grievink J, et al. On the robustness, effectiveness and reliability of chemical and mechanical heat pumps for low-temperature heat source district heating: a comparative simulation-based analysis and evaluation[J]. Energy, 2008, 33(6): 908-929.
[4] Kim T G, Yeo Y K, Song H K. Chemical heat pump based on dehydrogenation and hydrogenation of i‐propanol and acetone[J]. International Journal of Energy Research, 1992, 16(9): 897-916.
[5] Briggs R A, Taylor H S. The dehydrogenation of normal heptane and cyclohexane on cerium, vanadium and thorium oxide catalysts[J]. Journal of the American Chemical Society, 1941, 63(9): 2500-2503.
[6] Saito Y, Aramaki K, Hodoshima S, et al. Efficient hydrogen generation from organic chemical hydrides by using catalytic reactor on the basis of superheated liquid-film concept[J]. Chemical Engineering Science, 2008, 63(20): 4935-4941.
[7] Xin F, Xu M, Li X F, et al. Experimental study of isopropanol dehydrogenation over amorphous alloy raney nickel catalysts[J]. Journal of Thermal Science, 2013, 22(6): 613-618.
[8] Zhang L, Xu G, An Y, et al. Dehydrogenation of methyl-cyclohexane under multiphase reaction conditions[J]. International Journal of Hydrogen Energy, 2006, 31(15):2250-2255.
[9] Kariya N, Fukuoka A, Ichikawa M. Efficient evolution of hydrogen from liquid cycloalkanes over Pt-containing catalysts supported on active carbons under “wet–dry multiphase conditions”[J]. Applied Catalysis A: General, 2002, 233(1): 91-102.
[10] Sakurai M, Honda H, Kameyama H. Fundamental study of a non-steady operation for 2-propanol de-hydrogenation[J]. International journal of hydrogen energy, 2007, 32(9): 1303-1308.
[11] Shukla A A, Gosavi P V, Pande J V, et al. Efficient hydrogen supply through catalytic dehydrogenation of methylcyclohexane over Pt/metal oxide catalysts[J]. international journal of hydrogen energy, 2010, 35(9): 4020-4026.
[12] Ping H, Xu G, Wu S. System optimization of cyclohexane dehydrogenation under multiphase reaction conditions using the uniform design method[J]. international journal of hydrogen energy, 2015, 40(46): 15923-15932.
[13] Zhang L, Xu G, An Y, et al. Dehydrogenation of methyl-cyclohexane under multiphase reaction conditions[J]. International journal of hydrogen energy, 2006, 31(15): 2250-2255.
[14] Kou Z, Zhi Z, Xu G, et al. Investigation of the performance and deactivation behavior of Raney-Ni catalyst in continuous dehydrogenation of cyclohexane under multiphase reaction conditions[J]. Applied Catalysis A: General, 2013, 467(10): 196-201.
[15] Hao L, Zhen S, Tan D, et al. Preparation of novel Raney-Ni catalysts and characterization by XRD, SEM and XPS[J]. Applied Catalysis A General, 2001, 214(1):69-76.
[16] Mooksuwan W, Kumar S. Study on 2-propanol/acetone/hydrogen chemical heat pump: endothermic dehydrogenation of 2-propanol[J]. International journal of energy research, 2000, 24(12): 1109-1122.
[17] Xu M, Xin F, Li X, et al. Equilibrium model and performances of an isopropanol–acetone–hydrogen chemical heat pump with a reactive distillation column[J]. Industrial & Engineering Chemistry Research, 2013, 52(11): 4040-4048.
[18] Sakurai M, Honda H, Kameyama H. Fundamental study of a non-steady operation for 2-propanol de-hydrogenation[J]. International journal of hydrogen energy, 2007, 32(9): 1303-1308.
[19] Kariya N, Fukuoka A, Ichikawa M. Efficient evolution of hydrogen from liquid cycloalkanes over Pt-containing catalysts supported on active carbons under “wet–dry multiphase conditions”[J]. Applied Catalysis A: General, 2002, 233(1): 91-102.
[20] Kariya N, Fukuoka A, Utagawa T, et al. Efficient hydrogen production using cyclohexane and decalin by pulse-spray mode reactor with Pt catalysts[J]. Applied Catalysis A: General, 2003, 247(2): 247-259.
