富氧气氛下碳氢燃料同轴射流扩散火焰的形态特性

曹文健 任飞 相龙凯 冯艳 楚化强 顾明言

doi:10.12034/j.issn.1009-606X.217116

过程工程学报 >

2017 , Vol. 17 >Issue 3: 632 - 639

DOI: https://doi.org/10.12034/j.issn.1009-606X.217116

环境与能源

富氧气氛下碳氢燃料同轴射流扩散火焰的形态特性

曹文健任飞相龙凯冯艳楚化强顾明言

展开

安徽工业大学能源与环境学院，安徽马鞍山 243000

收稿日期: 2017-01-16

修回日期: 2017-04-02

网络出版日期: 2017-06-14

基金资助

汽油替代燃料层流扩散火焰中PAH和碳烟生成特性研究;基于高效非灰辐射模型的碳氢燃料燃烧产物特性研究

收起

Morphology Characteristics of Hydrocarbon Fuels Coflow Jet Diffusion Flame under Oxygen-enriched Atmosphere

Wenjian CAO Fei REN Longkai XIANG Yan FENG Huaqiang CHU Mingyan GU

Expand

School of Energy and Environment, Anhui University of Technology, Ma’anshan, Anhui 243002, China

Received date: 2017-01-16

Revised date: 2017-04-02

Online published: 2017-06-14

Fold

摘要

采用碳氢燃料燃烧实验台，在不同燃料流量和氧浓度下研究甲烷、乙烯同轴射流扩散火焰的火焰形态和温度变化，利用场发射扫描电镜观测不同位置的碳黑样本. 结果表明，氧浓度由21%(j)升至100%(j)时，甲烷、乙烯火焰高度下降79%，火焰边缘温度比中心温度分别高234和337℃，乙烯外焰的腰部位置出现“黄金区域”. 乙烯流量增至170 mL/min、氧浓度增至31%(j)时，火焰尖端出现“焰翅”，而甲烷火焰始终未见“焰翅”. 在乙烯火焰“黄金区域”大量积聚的碳黑颗粒具有很高的发射率，火焰亮度明显增强. 在火焰分层处，碳黑团聚体热解导致火焰温度出现波谷.

关键词： 同轴射流; 富氧燃烧; 火焰形态; 碳黑

本文引用格式

曹文健任飞相龙凯冯艳楚化强顾明言 . 富氧气氛下碳氢燃料同轴射流扩散火焰的形态特性[J]. 过程工程学报, 2017 , 17(3) : 632 -639 . DOI: 10.12034/j.issn.1009-606X.217116

Abstract

The flame morphology and temperature variation of methane and ethylene coflow jet diffusion flame at different fuel flow and oxygen concentration were studied on a hydrocarbon fuel combustion apparatus, and the soot samples at different positions in the flame were observed by field emission scanning electron microscope. The results showed that the oxygen concentration increased from 21%(j) to 100%(j), the flame height of methane and ethylene decreased by 79%, and the flame edge temperature was higher than the central temperature 232 and 337℃, respectively. In the waist of the outer flame of ethylene appears "golden area", when the ethylene flow rate increased to 170 mL/min and oxygen concentration increased to 31%(j), the flame tip appeared "flame wing", while the methane flame did not see "flame wing" at all. The large accumulation of soot particles in the "golden area" of the ethylene flame has a high emissivity, and thus the flame brightness is significantly enhanced. Due to the pyrolysis of the soot aggregate, the flame temperature appears valley in the flame stratification.

Key words： coflow jet; oxygen-enriched combustion; flame morphology; soot

参考文献

[1] Ramanathan V, Carmichael G. Global and regional climate changes due to black carbon[J]. Nature Geoscience, 2008, 1(4): 221-227.
[2] Jacobson M Z. Strong radiative heating due to the mixing state of black carbon in atmospheric aerosols[J]. Nature, 2001, 409(6): 695-697.
[3] Haynes B S. Wagner H G. Soot formation [J]. Progress in Energy and Combustion Science, 1981: 7: 229-273.
[4] 鲁冠军, 赵黛青, 杨浩林, 等. 甲烷/富氧射流扩散火焰NOx的排放特性[J]. 过程工程学报, 2007, 7(1): 29-33.
[5] 覃建果, 魏小林, 郭啸峰, 等. 甲烷高压富氧燃烧层流扩散火焰的数值研究[J]. 燃料科学与技术, 2013, 19(5): 425-433.
[6] 陈伟鹏, 朱秉深, 史庆祥, 等. 电磁场强度对层流火焰和NO生成特性的影响[J]. 过程工程学报, 2012, 12(6): 952-956.
[7] 张单. 微重力层流射流扩散火焰的图像特征与燃烧特性[D]. 合肥: 中国科学技术大学, 2014.
[8] 闫伟杰. 基于光谱分析和图像处理的火焰温度及辐射特性检测[D]. 武汉: 华中科技大学, 2014.
[9] 楚化强, 曹文健, 冯艳, 等. 二氧化碳和富氧空气对甲烷与乙烯燃烧的影响[J]. 过程工程学报, 2016,16(3): 470-476.
[10] Cheng Z, Pitz R W, Bennett B A, et al. Oxygen-enhanced high temperature laminar coflow flames [C]// 40th AIAA/ASME/SAE/ASEE Joint Propulsion Conference. Fort Lauderdale, FL: American Institute of Aeronautics and Astronautics, 2004, 3374-3384.
[11] Beltrame A, Porshnev P, Merchan-Merchan W, et al. Soot and NO formation in methane-oxygen enriched diffusion flames [J]. Combustion and Flame, 2001, 124(1-2): 295-310.
[12] 冯耀勋, 赵黛青, 贾明生, 等. 富氧空气/甲烷对向流扩散火焰的实验研究[J]. 湛江海洋大学学报, 2006, 26(4): 71-75.
[13] 赵黛青, 杨浩林, 鲁冠军, 等. 甲烷／富氧扩散火焰燃烧区域的分层特性研究[J]. 工程热物理学报, 2006, (S2): 131-134.
[14] Lee C E, Lee S R, Han J W, et al. Numerical study on effect of CO2 addition in flame structure and NOx formation of CH4–air counterflow diffusion flames[J]. International Journal of Energy Research, 2001, 25(4): 343-354.
[15] Oh K C, Shin H D. The effect of oxygen and carbon dioxide concentration on soot formation in non-premixed flames[J]. Fuel, 2006, 85: 615–624.
[16] Liu F S, Guo H S, Smallwood G J. Effect of gas and soot radiation on soot formation in a coflow laminar ethylene diffusion flame[J]. Joumal of Quantitative Spectroscopy & Radiative Transfer, 2001, 73(2-5): 501-511.
[17] 刘正东, 陈晓冰, 娄春. 基于碳氧原子比空间的富氧燃烧火焰结构及碳黑初生分析[J]. 燃烧科学与技术, 2016, 22(3): 276-281.
[18] Shim S H, Shin H D. Transition morphology of deposits on SiC fibers in propane/air laminar diffusion flames[J]. Combustion and Flame, 2002, 131(1-2): 210-218.
[19] Shim S H, Ahn K Y, Sang H J, et al. Study of deposit morphology in a propane diffusion-flame under fuel-rich conditions[J]. Applied Energy, 2004, 79(2): 179-189.
[20] Wang H, Frenklach M. A detailed kinetic modeling study of aromatics formation in laminar premixed acetylene and ethylene flames[J]. Combustion and Flame, 1997, 110(1): 173-221.
[21] Frenklach M, Wang H. Detailed modeling of soot particle nucleation and growth[J]. Proc. Comb. Inst., 1991, 23(1): 1559-1566.
[22] Boehman A L, Song J, Alam M. Impact of biodiesel blending on diesel soot and the regeneration of particulate filters[J]. Energy & Fuels, 2005, 19(5): 1857-1864.

Options

文章导航

模态框（Modal）标题

摘要

本文引用格式

Abstract

参考文献