研究了工程上常用的3种吸附剂CO2吸附剂硅胶、13X分子筛和碳分子筛在高压(0.1~1 MPa)下对CO2和CH4的吸附容量、稳定性和选择性，以确定其在沼气变压吸附分离中应用的可行性. 结果表明，硅胶的吸附稳定性非常好，0.1 MPa时吸附选择性系数为8~10，能有效分离CH4?CO2；13X分子筛对CH4和CO2吸附容量最高、吸附选择性最好，重复使用5次CO2的吸附容量略有下降；以CH4的损失率作为评价标准时，13X分子筛吸附CH4的损失率最低. 降压不能使被碳分子筛吸附的CH4完全解吸，吸附位不能充分释放，不适用于CH4与CO2的分离.
The adsorption capacity, adsorption stability and adsorption selectivity under high pressure (0.1~1 MPa) of three sorbents, silica gel, 13X molecular sieves and carbon molecular sieves, which were potentially used in biogas upgrading engineering, were investigated. The results showed that among the three adsorbents, silica gel had the best adsorption stability, and its adsorption selectivity coefficient under 0.1 MPa was between 8 and 10 which can achieve a effective separation of CO2 from CH4. 13X molecular sieve had the highest adsorption capacity for both CO2 and CH4, in addition, 13X molecular sieves had a significantly improved selectivity, however, the adsorption capacity for CO2 decreased continually when reused 5 times. When taking the environmentally important CH4 slip into account, 13X molecular sieve was the lowest. The desorption isotherms of carbon molecular sieves were always above the adsorption isotherm when reused for CH4 which means that the adsorbed CH4 and the adsorption sites cannot be fully released through depressurization, so it was not a good candidate for CO2/CH4 separation.
[1] 陈道远.变压吸附法脱除二氧化碳的研究 [D]. 南京：南京工业大学. 2003: 5-11. [2]Chen D Y.Remove carbon dioxide by PSA [D]. Nanjing: Nanjing university of technology. 2003: 5-10. [3]张孟宇，钟声，苏伟.分离吸附剂研究进展[J].天然气化工化学与化工, 2013, 38(1):84-88 [4]Zhang M Y, Zhong S, Su W.An overview of adsorbents for CO2 separation[J].Natural gas chemical industry (C1 chemistry and chemical engineering), 2013, 38(1):84-88 [5] Majchrzak A, Nowak W.Separation characteristics as a selection criteria of CO2 adsorbents [J][J].Journal of CO2 Utilization, 2017, 17(无):69-79 [6] Garshasbi V, Jahangiri M, Anbia M.Equilibrium CO2 adsorption on zeolite 13X prepared from natural clays [J]. Applied Surface Science, 2017, 393:225-233. [7] 于洁.变压吸附提纯沼气中CH4的试验研究[M]. 哈尔滨：东北农业大学. 2012年，12-16. [8]Yu J.Study on purifying the methane of the biogas by pressure swing adsorption [D]. Harbin: Northeast agricultural university. 2012: 12-16. [9] 杨海燕.分离CH4/CO2的吸附剂研究[D]. 哈尔滨：东北农业大学. 2013年，21-30. [10]Yang H Y.Research on adsorbents for separation of the CH4/CO2 mixture. Harbin: Northeast agricultural university. 2013: 21-30. [11]王志祥，易红宏，唐晓龙，等.不同吸附剂在沼气脱碳提纯中的分离性能[J].中南大学学报自然科学版, 2015, 46(9):3535-3539 [12]Wang Z X, Yi H H, Tang X L, et al.Adsorption separation performance of different adsorbents for biogas decarbonization upgrading[J].Journal of central south university( science and technology), 2015, 46(9):3535-3539 [13]李通，罗仕忠，吴永永，等.活性炭改性及其对吸附性能的研究[J].煤炭学报, 2011, 36(12):2012-2017 [14]Li T, Luo S Z, Wu Y Y, et al.Study of the modifying of activated carbon and its adsorption properties of CO2CH4 mixture[J].Journal of China coal society, 2011, 36(12):2012-2017 [15] 黄丞，刘建禹，丁宁，等.3种吸附剂不同压力下脱除沼气中CO2对比实验[J]. 农机化研究, 2014，(12): 240-242. [16]Huang C, Liu J Y, Ding N, et al.The contrast experiment of three types of adsorbents for removal of CO2 from biogas at different pressure [J]. Journal of agricultural mechanization research. 2014, (12): 240-242. [17]韩大明，周花蕾，李文军.用于吸附分离的碳分子筛的制备研究[J].河南化工, 2013, 30(5):41-44 [18]Han D M, Zhou H L, Li W J.Preparation of carbon molecular sieve for CH4/CO2 separation by adsorption [J]. Henan chemical industry. 2013, 30(5): 41-44. [19] Ferreira A F P, Ribeiro A M, Kula? S, et al.Methane purification by adsorptive processes on MIL-53(Al) [J]. Chemical Engineering Science. 2015, 124:79-95. [20] álvarez-Gutiérrez N, García S, Gil M V, et al.Towards bio-upgrading of biogas: biomass waste-based adsorbents [J]. Energy Procedia. 2014, 63:6527 – 6533. [21] Bacsik Z， Cheung O, Vasiliev P, et al.Selective separation of CO2 and CH4 for biogas upgrading on zeolite NaKA and SAPO-56 [J]. Applied Energy. 2016, 162: 613-621. [22] Montanari T, Finocchio E, Salvatore E, et al.CO2 separation and landfill biogas upgrading: A comparison of 4A and 13X zeolite adsorbents [J]. Energy. 2011, 36: 314-319 [23] Alonso-Vicario A, Ochoa-Gómez J R, Gil-Río S, et al, Purification and upgrading of biogas by pressure swing adsorption on synthetic and natural zeolites [J].Microporous and Mesoporous Materials 2010, 134: 100–107. [24] Simon C M, Smit B, Haranczyk M, pyIAST: Ideal Adsorbed Solution Theory (IAST) Python Package [J].Computer Physics Communications, 2016, 200(6):364-380. [25] Myers A L, Prausnitz J M.Thermodynamics of mixed-gas adsorption[J]. AIChE J. 1965, 11 (1) :121-127. [26]Walton K S, Sholl D S.Predicting Multicomponent Adsorption: 50 Years of the Ideal Adsorbed Solution Theory[J].AIChE J, 2015, 61(9):2757-2762
